Vulcan-Hart GRC 35 Especificaciones descargar pdf (Pagina 14)

– 14 –

DAILY FILTERING

Fryers Without Filter Ready Options

Turn gas valve off when draining or filling.

Always filter the shortening while liquified. A cold fryer will not drain properly because the shortening under

the cold zone tube area will remain hard, even if the heat is on for a few minutes. If necessary, the clean-

out rod may be used to carefully stir up hard fat to an area above the cold zone (see Fig. 2) where it will

melt. After the cold zone is liquified, turn the fryer thermostat and gas valve off.

Shortening life will be extended by filtering at least once a day or more often if conditions warrant. A

commercial power filter (available from other manufacturers) may be used. Follow the manufacturer's

operating instructions for draining, straining, and replacing shortening in the fry tank.

Another way to filter is to drain the shortening from the drain pipe through a filter bag, or cover the receiving

container with cheesecloth or other filtering material.

Filtering Procedure (Not Filter Ready)

1. Turn the fryer off.

2. Slowly remove the baskets, especially if shortening is hot, to prevent splashing.

3. Open the fryer door and attach the drain pipe to the drain valve.

4. Select a container of sufficient capacity and place it below the drain pipe.

5. If you are using a filter bag, tie it securely to the drain pipe. If other filter medium is used, place it in

the container.

6. Open the drain valve carefully so the oil stream is directed through the filter.

7.With a small amount of warm shortening, flush out scraps and sediment in the fry tank. Drain the tank

thoroughly and wipe clean.

8. Should it be necessary to clean the tank more thoroughly, follow the procedure shown in CLEANING

— WEEKLY OR AS REQUIRED in this manual.

9. Close the drain valve.

10. Pour strained shortening back into the tank.

11. Add shortening to the fill level line.

Filter-Ready Fryers Only

Follow instructions in the MOBILE FILTER OPERATING MANUAL shipped with the mobile filter. If the

manual is not found, contact your dealer to obtain the manual before operating the mobile filter.

1 2 ... 9 10 11 12 13 14 15 16 17 18 19 ... 23 24

Sin comentarios

Vulcan-Hart GRC 35 Especificaciones Pagina 14