Vulcan-Hart VL2GSS ML-52389 Manual de usuario Pagina 1

VULCAN-HART P.O. BOX 696, LOUISVILLE, KY 40201-0696DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC TEL. (502) 778-2791WWW.VULCANHART.COMFORM 35409 Rev. A (

– 10 –IGNITION SWITCHRESETBOILERON - OFFHI LIMITPRESSURELOW WATERDISCONNECT POWERBEFORE REMOVING THISOR ANY PANEL GIVINGACCESS TO PARTS.BOILER OPERATI

– 11 –AUTOMATIC BLOW DOWN VALVEGAS COMBINATION VALVEOPTIONAL MANUAL BLOW DOWN VALVEFig. 7

– 12 –STEAM COOKING — COMPARTMENT OPERATIONRefer to the Steam Cooking with Vulcan Kettles and Steamers (booklet packed with your steamer) forsuggested

– 13 –SELECTION OF PANS FOR STEAM COOKINGVL steamer compartments are designed to acceptcombinations of the following perforated or solidcooking pans (

– 14 –Separate frozen food packs into smaller chunks.If unpacked pre-cooked frozen dishes require more than 15 minutes to cook, cover the pan. When a

– 15 –DOOR GASKETSClean the gasket sealing surface of the compartment doors to remove harmful food acids for maximumgasket life. Do not use any solve

– 16 –WATER LEVEL GAUGECheck the water level gauge sight glass daily. The correct water level is approximately 1" (2.5 cm) ofwater visible in the

– 2 –IMPORTANT FOR YOUR SAFETYTHIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GASEQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD STAR

– 3 –TABLE OF CONTENTSGENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4INST

– 4 –Installation, Operation and Care ofVL2 & VL3 GAS FOOD STEAMERSSAVE THESE INSTRUCTIONS FOR FUTURE USEGENERALVulcan-Hart suggests that you thor

– 5 –INSTALLATION CODES AND STANDARDSIn the United States, the Vulcan steamer must be installed in accordance with state and local codes,with the Nati

– 6 –PLUMBING CONNECTIONSWARNING: PLUMBING CONNECTIONS MUST COMPLY WITH APPLICABLE SANITARY, SAFETYAND PLUMBING CODES.Water RequirementsProper water

– 7 –GAS CONNECTIONCAUTION: All gas supply connections and any pipe joint compound used must be resistant tothe action of liquefied petroleum gases.C

– 8 –INSTALLATION DRAWINGModels VL2GSS & VL3GSSFig. 3LEGENDGAS CONNECTION: 3/4" NPTBOILER FEED CONNECTION FOR FILTERED WATER: 1/4" NPTWA

– 9 –DRAIN REQUIREMENTSThe floor sink is not to be located under the steamer.Fig. 4